Contenu
Having a leak around a car rear windshield can be very annoying. If you dont take care of it quickly, your car interior can get soaked during a torrential rainstorm. During a smaller storm, it can get just wet enough to leave a lovely mildew smell and get water spots on the upholstery. That makes it important to fix the leak when you first notice it, before it has a chance to get any worse.
Instructions
Step 1
Locate the source of the leak. Ask a friend to pour a gallon of water on your rear windshield, moving the jug from left to right across the top, as you sit in the rear seat of the vehicle or in the hatch. As the water runs down the windshield, determine the spot where it starts coming inside the car. If the first gallon doesnt cause a leak, refill the jug and repeat as needed or use the garden hose.
Step 2
Take your screwdriver and gently pry the rubber window trim away from the windshield near the source of your leak, being careful not to bend or nick it. Check the channel (the metal well underneath the trim) for cracks or rust. Also inspect the bottom of the windshields glass for nicks, chips or cracks.
Step 3
Wipe out the channel with a cotton rag dipped in rubbing alcohol so you have a smooth surface to work with. Sand off any rust with 80-grit sandpaper and wipe out any fragments. Fill the channel with polyurethane sealant using your caulking gun, leaving an eighth of an inch of space at the top of the channel to accommodate the trim. Before the caulk has a chance to dry, replace the trim you lifted up. Secure it in place with duct tape. The pressure on the caulk will help stick it back to the window, leaving it lying flat.
Allow the caulk 30 minutes to dry, then remove the tape. Repeat the water test from Step 1 to ensure that youve taken care of the problem. If not, add more caulk and try again.
Tip
- Tape plastic sheeting over the entire inside of your windshield, including the channels, to keep your car dry until you have a chance to fix the leak.
Warning
- If the problem is a crack in the glass, not a nick or a chip, contact your insurance company. Its a good idea to replace your entire rear windshield since cracks have a bad habit of getting bigger with time.The repair cost is often covered under comprehensive claims.
Items you will need
- One-gallon jug or garden hose Flathead screwdriver Rough sandpaper Cotton rag Rubbing alcohol Duct tape Polyurethane caulk Caulking gun
